Welcome to Stallard Kane Associates

Glasgow firm fined after worker killed

Daniel Hurley, then aged 31 years, who was born in Ireland but was living in Glasgow, was employed as a groundworker by a company sub-contracted by Morris & Spottiswood to work on a major development of flats and houses in Maryhill, Glasgow.

Glasgow Sheriff Court heard that Mr Hurley had been operating a ‘whacker’ machine to compact hardcore next to an area where the structural steelwork for a stair tower was being erected on the site in Murano Street.

But after the steel frame had been lowered into position and the lifting chains released, it then began to tilt and fall towards Mr Hurley, pulling three anchor bolts clear out of the ground, while the fourth was snapped in half.

One of the steel erectors shouted a warning and Mr Hurley began to run, but he was struck by the top beam of the frame across his shoulders and neck forcing him down onto the ground and causing fatal crush injuries.

The incident, on 15 October 2009, was investigated by the Health and Safety Executive (HSE) and Police Scotland, which found serious safety failings in the way Morris & Spottiswood Ltd as principal contractor had managed the project.

The court was told that the steel fabrication company sub-contracted to design the steelwork and a second company commissioned to erect it, were also both found to be at fault but had since ceased trading.

The investigation found that remaining foundation resin anchor bolts installed by Morris and Spottiswood Ltd were so poorly installed that they could be moved by hand and one was so loose that it was pulled out of the concrete foundation by the investigating inspector. The failure to check the bolts capacity by the sub-contractors combined with the chosen method of erection had contributed to the cause of the fatal collapse.

Morris & Spottiswood had failed to review the risk assessments and method statements submitted by the steelwork sub-contractor for the task and had failed to establish and maintain an exclusion zone around the steelwork while erection was being carried out.

Following the incident, Morris & Spottiswood Ltd contracted a specialist company to replace all of the anchor bolts they had previously installed for this phase of the project. Metal fence panels available on site were also used to create exclusion zones around any remaining steel erection works.

Morris & Spottiswood Ltd, of Helen Street, Glasgow, was fined £200,000 after pleading guilty to breaching Section 3(1) of the Health and Safety at Work etc. Act 1974.

Daniel Hurley, then aged 31 years, who was born in Ireland but was living in Glasgow, was employed as a groundworker by a company sub-contracted by Morris & Spottiswood to work on a major development of flats and houses in Maryhill, Glasgow.

Glasgow Sheriff Court heard that Mr Hurley had been operating a ‘whacker’ machine to compact hardcore next to an area where the structural steelwork for a stair tower was being erected on the site in Murano Street.

But after the steel frame had been lowered into position and the lifting chains released, it then began to tilt and fall towards Mr Hurley, pulling three anchor bolts clear out of the ground, while the fourth was snapped in half.

One of the steel erectors shouted a warning and Mr Hurley began to run, but he was struck by the top beam of the frame across his shoulders and neck forcing him down onto the ground and causing fatal crush injuries.

The incident, on 15 October 2009, was investigated by the Health and Safety Executive (HSE) and Police Scotland, which found serious safety failings in the way Morris & Spottiswood Ltd as principal contractor had managed the project.

The court was told that the steel fabrication company sub-contracted to design the steelwork and a second company commissioned to erect it, were also both found to be at fault but had since ceased trading.

The investigation found that remaining foundation resin anchor bolts installed by Morris and Spottiswood Ltd were so poorly installed that they could be moved by hand and one was so loose that it was pulled out of the concrete foundation by the investigating inspector. The failure to check the bolts capacity by the sub-contractors combined with the chosen method of erection had contributed to the cause of the fatal collapse.

Morris & Spottiswood had failed to review the risk assessments and method statements submitted by the steelwork sub-contractor for the task and had failed to establish and maintain an exclusion zone around the steelwork while erection was being carried out.

Following the incident, Morris & Spottiswood Ltd contracted a specialist company to replace all of the anchor bolts they had previously installed for this phase of the project. Metal fence panels available on site were also used to create exclusion zones around any remaining steel erection works.

Morris & Spottiswood Ltd, of Helen Street, Glasgow, was fined £200,000 after pleading guilty to breaching Section 3(1) of the Health and Safety at Work etc. Act 1974.

Added: 25-06-2015
Back

Breaking News

Head Office:
First Floor Offices, 11-23 Market St.
Gainsborough, Lincolnshire
DN21 2BL

Tel: 01427 678660
 

HR and Accounts:
26/26a Hickman Street
Gainsborough, Lincolnshire
DN21 2DZ

Tel: 01427 678660
 

Hull Office:
West 1, West Dock Street
Hull HU3 4HH

Tel: 01482 534 348
 

Manchester Office:
Hyde Park House, Cartwright Street
Newton, Hyde, Cheshire SK14 4EH

Tel: 0161 367 1214
 

Birmingham Office:
2450 Regents Court The Crescent
Birmingham Business Park Solihull B37 7YE

Tel: 0121 69 59 290
 

London Office:
4th Floor, 86-90 Paul Street
London EC2A 4NE

Tel: 0207 111 0958